Announcement

Collapse

Get more Tips, Specs and Technical Data!

Did you know... this Forum is a service of the Studebaker Drivers Club? For more technical tips, specifications, history and tech data, visit the Tech Tips page at the SDC Homepage: www.studebakerdriversclub.com/tips.asp
See more
See less

51 Commander fuel tank?

Collapse
X
 
  • Filter
  • Time
  • Show
Clear All
new posts

  • Fuel System: 51 Commander fuel tank?

    In the process of getting my car the fuel tank was dented. I don't know if it is sealed well on the inside or not (either way I am going to redo that). But wondering where I could get another tank and how to check if the inside of the tank is good?

    Or instead of a new tank... are there any remedies for getting a dent out of the tank?

    Thanks,
    ~Jon

  • #2
    Remove the five small screws holding the fuel tank gauge sending unit to the tank, accessed through the hole in the trunk floor and shine a light inside to view the condition/damage to your tank. These tanks are originally galvanized inside and out to prevent rust, but over the years will rust through and require the "sealing" you mention that was never required before. Radiator Shops will clean and seal gas tanks for you.

    There are NO New tanks, some good used, can sometimes be found however.
    Also dents can sometimes be pushed back out by going through the sender hole.
    StudeRich
    Second Generation Stude Driver,
    Proud '54 Starliner Owner

    Comment


    • #3
      Originally posted by StudeRich View Post
      dents can sometimes be pushed back out by going through the sender hole.
      And, if the tank has been totally devoid of gas fumes, a body shop can weld a stud specifically designed for pulling dents out. The stud is then ground off and the surface repainted.
      With no new tanks available extra effort is required to salvage what we still have.
      "All attempts to 'rise above the issue' are simply an excuse to avoid it profitably." --Dick Gregory

      Brad Johnson, SDC since 1975, ASC since 1990
      Pine Grove Mills, Pa.
      sigpic'33 Rockne 10, '51 Commander Starlight, '53 Commander Starlight "Désirée"

      Comment


      • #4
        With the fenders and filler tube removed, I recently shot a photo looking into my gas tank (same as yours) and was pleasantly surprised to see a very shiny silver lining. I hope that yours is the same in this respect. I previously had a 51 Champion that I needed to get steamed and lined to keep the rust from choking my inline fuel filter.

        BTW, What color is your car? Is it Comanche Red or Black Cherry? Look under the glove box and the name of the original color should be printed there.

        Jim
        Last edited by StudeMann; 09-01-2011, 11:40 PM.
        \"Ahh, a bear in his natural habitat...a Studebaker!\"

        51 Land Cruiser (Elsie)
        Jim Mann
        Victoria, B.C.
        Canada

        Comment

        Working...
        X